Product ID:ALUMNIGRIP LINEAR POLYURETHANE TOPCOAT
MSDS Date:11/14/1990
FSC:8010
NIIN:00F051765
MSDS Number: CCFRR

US PAINT CORPORATION (FORMERLY GROU GROUP INC)

831 S 21ST ST
ST LOUIS, MO 63103-3043
US

Emergency Phone: 314-621-0525/202-483-7616

Info Phone: 314-621-0525/202-483-7616

Cage: EO831

US PAINT CORPORATION

ST LOUIS, MO 63103-3092 US

Telephone: 314-621-0525

Cage: EO831

CELLOSOLVE ACETATE (ETHYLENE GLYCOL ETHYL ETHER ACETATE),

CAS: 111-15-9

RTECS: KK8225000

Fraction By Weight: 16-27%

OSHA PEL 100 PPM

ACGIH TLV: 5 PPM SKIN

DIISOBUTYL KETONE

CAS: 108-83-8

RTECS: MJ5775000

Fraction By Weight: 2-4%

OSHA PEL 50 PPM

ACGIH TLV: 145 MG/CUM

PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 5-21%

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 3-5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

475-592 GMS/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION.
SKIN: CAN CAUSE DERMATITIS. INHALATION: CAN CAUSE NASAL &
RESPIRATORY IRRITATION. INGESTION: HARMFUL CAN CAUSE A BURNING
SENSATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS, ASPHYXIATION, TIGHTNESS IN CHEST, SORE THROAT,
ABDOMINAL PAIN, NAUSEA, VOMITIN G & DIARRHEA.

First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
AMOUNTS OF WATER FOR 15 MINS. EYES: FLUSH W/LARGE AMOUNTS OF WATER
FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE
TO FRESH AIR. IF BREATHING IS DIFFICULT GIVE OXYGEN. IF BREATHING
HAS STOPPED GIVE CPR. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:82F
Lower Limits:1.1
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:USE SCBA.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL LONG DISTANCES & BEYOND
CLOSED DOORS TO IGNITION SOURCE & IGNITE.

Spill Release Procedures:SMALL: ABSORB ON INERT MATERIAL SUCH AS PAPER,
VERMICULITE, FLOOR ABSORBENT & TRANSFER TO HOOD. LARGE: ELIMINATE
ALL SOURCES OF IGNITION. STOP SPILL SOURCE. CONTAIN TO PREVENT
SPREADING, PUMP INTO SAL VAGE TANK. (SUPP)

Handling and Storage Precautions:CLOSE TIGHT & UPRIGHT. KEEP CONTAINER
CLOSED WHEN NOT IN USE. DON'T STORE ABOVE 120F. CONTAINERS RETAIN
PRODUCT RESIDUES.

Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR
DURING & AFTER APPLICATION UNLESS LEVELS ARE BELOW APPLICABLE
LIMITS.
Ventilation:ADEQUATE
Protective Gloves:IMPERMEABLE
Eye Protection:SOLVENT RESISTANT W/SPLASH GUARDS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPILLS CONT'D: REMAINING LIQUID MAY BE ABSORBED W/INERT MATERIAL SUCH
AS SAND, CLAY/VERMICULITE.

Boiling Pt:B.P. Text:278-343F
Vapor Density:>1
Spec Gravity:1.05-1.37
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:50-63

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:FUMES CONTAINING CO, CO2.

Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD
BEING SURE TO ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR
HOOD DUCT WORK. DON'T INCINERATE. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS. UN 1 263

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.